Teriyaki Japan

EHS observed raw beef being stored above raw vegetables in walk in cooler. Violation: (c) Packaged and Unpackaged Food - Separation, Packaging, and Segregation.

1. Food shall be protected from cross contamination by:

(i) Except as specified in paragraph (i)(IV) of this subsection, separating raw animal foods during storage, preparation, holding, and display from:

(I) Raw ready-to-eat food including other raw animal food such as fish for sushi or molluscan shellfish, or other raw ready-to-eat food such as fruits and vegetables, P and

(II) Cooked ready-to-eat food; and P

(III) Fruits and vegetables before they are washed; P

(IV) Frozen, commercially processed and packaged raw animal food may be stored or displayed with or above frozen, commercially processed and packaged, ready-to-eat food.

(ii) Except when combined as ingredients, separating types of raw animal foods from each other such as beef, fish, lamb, pork, and poultry during storage, preparation, holding, and display by:

(I) Using separate equipment for each type, P or

(II) Arranging each type of food in equipment so that cross contamination of one type with another is prevented, P and

(III) Preparing each type of food at different times or in separate areas; P

(iii) Cleaning and sanitizing equipment and utensils;

(v) Cleaning hermetically sealed containers of food of visible soil before opening;

(vi) Protecting food containers that are received packaged together in a case or overwrap from cuts when the case or overwrap is opened;

(vii) Storing damaged, spoiled, or recalled food being held in the food service establishment separate from food, equipment, utensils, linens and single-service and single-use articles; or

(viii) Separating fruits and vegetables, before they are washed from ready-to-eat food. CA: EHS instructed PIC to discard vegetables.

EHS observed yum yum sauce stored on ice bath on make line with temperatures between 52-63 degrees Fahrenheit. EHS observed no ice touching the bottom of pan.

(f) Time/Temperature Control for Safety Food, Hot and Cold Holding. Except during preparation, cooking, or cooling, or when time is used as the public health control, time/temperature control for safety food shall be maintained at 41°F (5°C) or below or 135°F (57°C) or above, except that roasts cooked to a temperature and for a time specified in subsection (5)(a)2 of this Rule and reheated using the same temperature and time conditions as cooking may be held at a temperature of 130°F (54°C) or above. P PIC tossed yum yum sauce and replaced them. EHS temped yum yum sauce from REF and it was 41 degrees Fahrenheit. This was COS.

Observed meats stored in grocery bags in deep chest freezer without labels or names to identify food

(d) Food Storage Containers, Identified with Common Name of Food. Except for containers holding food that can be readily and unmistakably recognized, such as dry pasta, working containers holding food or food ingredients that are removed from their original packages for use in the food establishment, such as cooking oils, flour, herbs, potato flakes, salt, spices, and sugar shall be clearly and legibly identified, in English, with the common name of the food.

Observed male employee on his phone when EHS arrived. The employee then proceeded to put teriyaki sauce on a prepared order without washing his hands. EHS informed PIC of the issue and the corrective action. The same employee later began preparing an order after coming from the dining area and being on his phone without washing his hands. EHS informed PIC that the employee should stop the order, replace contaminated utensils and wash hands; employee washed hands incorrectly and EHS had inform PIC to inform staff of proper handwashing. (c) When to Wash.

1. Food employees shall clean their hands and exposed portions of their arms immediately before engaging in food preparation including working with exposed food, clean equipment and utensils, and unwrapped single-service and single-use articles P and:

(i) After touching bare human body parts other than clean hands and clean, exposed arms; P

(ii) After using the toilet room; P

(iii) After caring for or handling service animals or aquatic animals; P

(iv) After coughing, sneezing, using a handkerchief or disposable tissue, using tobacco, eating, or drinking, except for drinking from a closed beverage container and the container is handled to prevent contamination of the hands; P

(v) After handling soiled equipment or utensils; P

(vi) During food preparation, as often as necessary to remove soil and contamination and to prevent cross contamination when changing tasks; P

(vii) When switching between working with raw food and working with ready-to-eat food; P

(viii) Before donning gloves to initiate a task that involves working with food; P and

(ix) After engaging in other activities that contaminate the hands. P

2. All employees shall wash hands before leaving the restroom. All food employees leaving the restroom shall wash their hands again upon re-entering the food preparation area. EHS informed PIC to inform staff of the need to wash hands when any form of contamination occurs.

Observed male employee wash hands by rinsing them under water. b) Cleaning Procedure.

1. Except as specified in paragraph 4 of this subsection, food employees shall clean their hands and exposed portions of their arms, including surrogate prosthetic devices for hands or arms, for at least 20 seconds, using a cleaning compound in a handwashing sink that is properly equipped. P

2. Food employees shall use the following cleaning procedure in the order stated to clean their hands and exposed portions of their arms, including surrogate prosthetic devices for hands and arms:

(i) Rinse under clean, running warm water; P

(ii) Apply an amount of cleaning compound recommended by the cleaning compound manufacturer; P

(iii) Rub together vigorously for at least 10 to 15 seconds while:

(I) Paying particular attention to removing soil from underneath the fingernails during the cleaning procedure, P and

(II) Creating friction on the surfaces of the hands and arms or surrogate prosthetic devices for hands and arms, finger tips, and areas between the fingers; P

(iv) Thoroughly rinse under clean, running warm water; P and

(v) Immediately follow the cleaning procedure with thorough drying using disposable paper towels, a continuous towel system, or a heated-air hand drying device. P

3. To avoid recontaminating their hands or surrogate prosthetic devices, food employees may use disposable paper towels or similar clean barriers when touching surfaces such as manually operated faucet handles on a handwashing sink or the handle of a restroom door.

4. If approved and capable of removing the types of soils encountered in the food operations involved, an automatic handwashing facility may be used by food employees to clean their hands or surrogate prosthetic devices.

EHS informed PIC of the issue and the corrective action; PIC instructed employee to wash hands correctly.

Observed white substance in a bucket labeled food flavor on bottom shelf near chest freezer and with the chinese/spanish name; 4 liquid squirt bottles at the hibachi station with no labels. d) Food Storage Containers, Identified with Common Name of Food. Except for containers holding food that can be readily and unmistakably recognized, such as dry pasta, working containers holding food or food ingredients that are removed from their original packages for use in the food establishment, such as cooking oils, flour, herbs, potato flakes, salt, spices, and sugar shall be clearly and legibly identified, in English, with the common name of the food. Facility is to label items with the English and Spanish common name.

Observed fryer on prep table in kitchen; not under hood suppression system. (jj) Food Service Equipment, Acceptability. Food service equipment must be commercial grade equipment and designed and built according to standards set by American National Standards Institute (ANSI) accredited certification programs. Such an accredited program includes, but is not limited to, one offered by the National Sanitation Foundation, or Underwriters Laboratories. Food equipment that is certified or classified for sanitation by an American National Standards Institute (ANSI) accredited certification program is deemed to comply with subsections (1) and (2) of this Rule when used for its intended purpose. EHS informed PIC that he could not use the fryer; he must purchase a commercial grade fryer to sit under the hood suppression system.

Observed facility's need to clean grease and residue accumulation from various walls and baseboard; grease from ceiling vents, and rodent droppings in the dry storage area. b) Cleaning, Frequency and Restrictions.

1. The physical facilities shall be cleaned as often as necessary to keep them clean and by methods that prevent contamination of food products.

2. Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of food is exposed, such as after closing. EHS informed PIC of the need to clean the noted areas and any other areas requiring routine cleaning.

Observed white substance in a bucket labeled food flavor on bottom shelf near chest freezer and with the chinese/spanish name; 4 liquid squirt bottles at the hibachi station with no labels. d) Food Storage Containers, Identified with Common Name of Food. Except for containers holding food that can be readily and unmistakably recognized, such as dry pasta, working containers holding food or food ingredients that are removed from their original packages for use in the food establishment, such as cooking oils, flour, herbs, potato flakes, salt, spices, and sugar shall be clearly and legibly identified, in English, with the common name of the food. Facility is to label items with the English and Spanish common name.

Observed fryer on prep table in kitchen; not under hood suppression system. (jj) Food Service Equipment, Acceptability. Food service equipment must be commercial grade equipment and designed and built according to standards set by American National Standards Institute (ANSI) accredited certification programs. Such an accredited program includes, but is not limited to, one offered by the National Sanitation Foundation, or Underwriters Laboratories. Food equipment that is certified or classified for sanitation by an American National Standards Institute (ANSI) accredited certification program is deemed to comply with subsections (1) and (2) of this Rule when used for its intended purpose. EHS informed PIC that he could not use the fryer; he must purchase a commercial grade fryer to sit under the hood suppression system.

Observed walls and ceiling tiles stained or with food splatter. (b) Cleaning, Frequency and Restrictions.

1. The physical facilities shall be cleaned as often as necessary to keep them clean and by methods that prevent contamination of food products.

2. Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of food is exposed, such as after closing. EHS informed PIC of the need to clean walls and ceiling tiles.