CHECKER'S DRIVE-IN RESTAURANT #6154

Observed cheese sauce and chili not cooked to the proper temperature. (e) Manufacturer Cooking Instructions.

1. Commercially packaged food that bears a manufacturer’s cooking instructions shall be cooked according to those instructions before use in ready-to-eat foods or offered in unpackaged form for human consumption, unless the manufacturer’s instructions specify that the food may be consumed without cooking.P

2. Food for which the manufacturer has provided information that it has not been processed to control pathogens, when used in ready-to-eat foods or offered for human consumption, shall be cooked according to a time and temperature appropriate for the food. Product was reheated to the correct temperature.

Observed the need to repair any cracked floor tiles as they were holding water. (5) Maintenance and Operation.

(a) Good Repair. All physical facilities shall be maintained in good repair. Management is to speak with the owner about any repairs.

Observed sewage odor at the back of the facility; no visible sewage present nor did the floor drain look like it was holding anything. (5) Maintenance and Operation.

(a) Good Repair. All physical facilities shall be maintained in good repair.

(b) Cleaning, Frequency and Restrictions.

1. The physical facilities shall be cleaned as often as necessary to keep them clean and by methods that prevent contamination of food products.

2. Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of food is exposed, such as after closing. Management is to speak with the owner about the issue as it was stated during a informal visit to the facility that the lines were being cleaned but the company didn't bring to right tools to finish the job.

Observed food within reach in cooler under steam table at temperatures of 41F or above. Employee mentioned food was there since last night.

511-6-1.04(6)(f) - Time/Temperature Control for Safety; Cold Holding (P) (f) Time/Temperature Control for Safety Food, Hot and Cold Holding. Except during preparation, cooking, or cooling, or when time is used as the public health control, time/temperature control for safety food shall be maintained at 41°F (5°C) or below or 135°F (57°C) or above, except that roasts cooked to a temperature and for a time specified in subsection (5)(a)2 of this Rule and reheated using the same temperature and time conditions as cooking may be held at a temperature of 130°F (54°C) or above. P

Corrective action: Food was discarded, PIC mentioned that unit was not suppose to be used.

Observed no paper towels at handwash sink (towards the right side of the facility).

511-6-1.07(3)(b) - Hand Drying Provision (Pf) (b) Hand Drying Provision. Each handwashing sink or group of adjacent handwashing sinks shall be provided with:

1. Individual, disposable towels; Pf

2. A continuous towel system that supplies the user with a clean towel; Pf

3. A heated-air hand drying device; Pf or

4. A hand drying device that employs an air-knife system that delivers high velocity, pressurized air at ambient temperatures.Pf

Corrective action: Had PIC place a new roll of paper towel at handwash sink location

Observed box of ice cream cones within the box on the floor.

511-6-1.04(4)(q) - Food Storage (C) (q) Food Storage.

1. Except as specified in paragraphs 2 and 3 of this subsection, food shall be protected from contamination by storing the food:

(i) In a clean, dry location;

(ii) Where it is not exposed to splash, dust, or other contamination; and

(iii) At least 6 inches (15 cm) above the floor.

2. Food in packages and working containers may be stored less than 6 inches (15 cm) above the floor on case lot handling equipment if the equipment can be moved by hand or by conveniently available apparatuses such as hand trucks and forklifts.

3. Pressurized beverage containers, cased food in waterproof containers such as bottles or cans, and milk containers in plastic crates may be stored on a floor that is clean and not exposed to floor moisture.

Corrective action: SPoke to PIC, box was moved out from the floor.

Observed ceiling tiles missing, around fryers and dry storage.

511-6-1.07(5)(a),(b) - Good Repair, physical facilities maintained; Cleaning, Frequency & Restrictions, cleaned often enough to keep them clean (C) (5) Maintenance and Operation.

(a) Good Repair. All physical facilities shall be maintained in good repair.

(b) Cleaning, Frequency and Restrictions.

1. The physical facilities shall be cleaned as often as necessary to keep them clean and by methods that prevent contamination of food products.

2. Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of food is exposed, such as after closing.

3. If present, playground equipment and associated areas shall be maintained in a clean and sanitary condition. In addition, a cleaning and sanitizing plan along with cleaning and sanitizing records for playground equipment and associated areas shall be maintained within the food service establishment for review upon request by the Health Authority. Further, such cleaning and sanitizing plan for employees to follow in the event of encountering vomitus or fecal matter shall be included and submitted at the time of permit application as specified in DPH Rule 511-6-1-.02(1)(c). Pf

Corrective action: Spoke to PIC, about have ceiling tiles repaired or replaced.

Observed accumulation of debris behind machines and corners of the facility.

511-6-1.07(5)(a),(b) - Good Repair, physical facilities maintained; Cleaning, Frequency & Restrictions, cleaned often enough to keep them clean (C) (5) Maintenance and Operation.

(a) Good Repair. All physical facilities shall be maintained in good repair.

(b) Cleaning, Frequency and Restrictions.

1. The physical facilities shall be cleaned as often as necessary to keep them clean and by methods that prevent contamination of food products.

2. Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of food is exposed, such as after closing.

3. If present, playground equipment and associated areas shall be maintained in a clean and sanitary condition. In addition, a cleaning and sanitizing plan along with cleaning and sanitizing records for playground equipment and associated areas shall be maintained within the food service establishment for review upon request by the Health Authority. Further, such cleaning and sanitizing plan for employees to follow in the event of encountering vomitus or fecal matter shall be included and submitted at the time of permit application as specified in DPH Rule 511-6-1-.02(1)(c). Pf

Corrective action: Spoke to PIC to increase cleaning frequency of the facility.

Observed ice machine continuously leaking water on the floor.

511-6-1.05(6)(a) - Good Repair & Proper Adjustment (C) (6) Maintenance and Operation.

(a) Good Repair and Proper Adjustment.

1. Equipment shall be maintained in a state of repair and condition that meets the requirements specified under subsections (1) and (2)of this Rule.

2. Equipment components such as doors, seals, hinges, fasteners, and kick plates shall be kept intact, tight, and adjusted in accordance with manufacturer's specifications.

3. Cutting or piercing parts of can openers shall be kept sharp to minimize the creation of metal fragments that can contaminate food when the container is opened.

Corrective action: SPoke with PIC, to have maintenance fix machine.

Observed three compartment unable to hold water properly on the wash compartment side.

511-6-1.05(6)(a) - Good Repair & Proper Adjustment (C) (6) Maintenance and Operation.

(a) Good Repair and Proper Adjustment.

1. Equipment shall be maintained in a state of repair and condition that meets the requirements specified under subsections (1) and (2)of this Rule.

2. Equipment components such as doors, seals, hinges, fasteners, and kick plates shall be kept intact, tight, and adjusted in accordance with manufacturer's specifications.

3. Cutting or piercing parts of can openers shall be kept sharp to minimize the creation of metal fragments that can contaminate food when the container is opened.

Corrective action: Spoke with PIC, to have mechanism that enables compartment to hold water fixed.

Observed hood vent for fryers missing one of its panels. After further look panel was leaning on a corner of the facility.

511-6-1.05(6)(a) - Good Repair & Proper Adjustment (C) (6) Maintenance and Operation.

(a) Good Repair and Proper Adjustment.

1. Equipment shall be maintained in a state of repair and condition that meets the requirements specified under subsections (1) and (2)of this Rule.

2. Equipment components such as doors, seals, hinges, fasteners, and kick plates shall be kept intact, tight, and adjusted in accordance with manufacturer's specifications.

3. Cutting or piercing parts of can openers shall be kept sharp to minimize the creation of metal fragments that can contaminate food when the container is opened.

Corrective action: Spoke to PIC, to have panel placed back on the unit and clean hoods if necessary. (Next Hood inspection marked for August 6th, 2025)

Observed steam table with washcloth within the heated water. PIC explained that the wash cloth is there to clog opening as water drains from steam table without it.

511-6-1.05(6)(a) - Good Repair & Proper Adjustment (C) (6) Maintenance and Operation.

(a) Good Repair and Proper Adjustment.

1. Equipment shall be maintained in a state of repair and condition that meets the requirements specified under subsections (1) and (2)of this Rule.

2. Equipment components such as doors, seals, hinges, fasteners, and kick plates shall be kept intact, tight, and adjusted in accordance with manufacturer's specifications.

3. Cutting or piercing parts of can openers shall be kept sharp to minimize the creation of metal fragments that can contaminate food when the container is opened.

Corrective action: Spoke to PIC, to have steam table repaired.

Observed sanitizing compartment of three compartment sink with excess food debris.

511-6-1.05(6)(d),(e) - Warewashing Equipment, Cleaning Frequency; Warewashing Machines, Manufacturers' Operating Instructions (C) (d) Warewashing Equipment, Cleaning Frequency. A warewashing machine; the compartments of sinks, basins, or other receptacles used for washing and rinsing equipment, utensils, or raw foods, or laundering wiping cloths; and drainboards or other equipment used to substitute for drainboards shall be cleaned before use; throughout the day at a frequency necessary to prevent recontamination of equipment and utensils and to ensure that the equipment performs its intended function; and if used, at least every 24 hours.

Corrective action: Corrective action: Spoke with PIC to increase cleaning frequency.

Observed garbage bags within the outside perimeter of the dumpsters.

511-6-1.06(5)(r),(s) - Frequency, removal of refuse, recyclables and returnables often enough to minimize odors and attracting pests; Receptacles or Vehicles, removal from premises in approved manner (C) (r) Frequency. Refuse, recyclables, and returnables shall be removed from the premises at a frequency that will minimize the development of objectionable odors and other conditions that attract or harbor insects and rodents.

(s) Receptacles or Vehicles. Refuse, recyclables, and returnables shall be removed from the premises by way of:

1. Portable receptacles that are constructed and maintained according to law; or

2. A transport vehicle that is constructed, maintained, and operated according to law.

Corrective action: Spoke with PIC, to have garbage removed at a proper frequency.

Observed cracked floor tiles throughout facility.

511-6-1.07(5)(a),(b) - Good Repair, physical facilities maintained; Cleaning, Frequency & Restrictions, cleaned often enough to keep them clean (C) (5) Maintenance and Operation.

(a) Good Repair. All physical facilities shall be maintained in good repair.

(b) Cleaning, Frequency and Restrictions.

1. The physical facilities shall be cleaned as often as necessary to keep them clean and by methods that prevent contamination of food products.

2. Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of food is exposed, such as after closing.

3. If present, playground equipment and associated areas shall be maintained in a clean and sanitary condition. In addition, a cleaning and sanitizing plan along with cleaning and sanitizing records for playground equipment and associated areas shall be maintained within the food service establishment for review upon request by the Health Authority. Further, such cleaning and sanitizing plan for employees to follow in the event of encountering vomitus or fecal matter shall be included and submitted at the time of permit application as specified in DPH Rule 511-6-1-.02(1)(c). Pf

Corrective action: Spoke with PIC, to have floor tiles repaired or replaced.

EHS requested for employee health forms from PIC. PIC could not provide records.

Corrective action- PIC must provide employee health forms for all staff.

511-6-1.03(2)(m) - Person-in-Charge Duties (Pf) Food employees and conditional employees are informed in a verifiable manner of their responsibility to report in accordance with the Chapter, to the person in charge, information about their health and activities as they relate to diseases that are transmissible through food; Pf and

Observed an accumulation of flies in the facility during the inspection.The presence of insects, rodents, and other pests shall be controlled to minimize their presence on the premises by:

1. Routinely inspecting incoming shipments of food and supplies;

2. Routinely inspecting the premises for evidence of pests;

3. Using methods, if pests are found, such as trapping devices or other means of pest control as specified under subsections (6)(e), (6)(m), and (6)(n) of this Rule; Pf and

4. Eliminating harborage conditions. PIC is to have a fly treatment and remind employees about keeping the doors closed when not in use.

EHS observed shelves that is storing dipping sauce and single use items with debris on them.

Correction action- PIC needs to make sure that shelves are free from any debris or spills.

511-6-1.05(7)(d) - Nonfood-Contact Surfaces (C) (d) Nonfood-Contact Surfaces. Nonfood-contact surfaces of equipment shall be cleaned at a frequency necessary to preclude accumulation of soil residues.

EHS observed items on line above required 41F. Violation: time/temperature control for safety foods shall be maintained at 41F or below unless being prepared, cooled, cooked, or time is used as public health control. CA: PIC discarded items.

EHS observed multiple items in walk in cooler with temperatures above required 41F. Violation: time/temperature control for safety foods shall be maintained at 41F or below unless being prepared, cooled, cooked, or time is used as public health control. CA: PIC discarded items.

EHS observed facility with no key drop delivery service agreement and no evidence of temperatures being taken when key drop deliveries are made. Violation: key drop deliveries shall have service agreement and temperatures recorded on the invoice in accordance with 511-6-1.04(3)(m). CA: obtain copy of service agreement and keep at store. Ensure drivers recording temperatures.

EHS observed stickers and sticker residues on food containers stored as clean. Violation: non-food contact surfaces of equipment shall be kept clean of residues. CA: wash and ensure all residue is removed from containers.