ZAXBY'S

Observed sanitizer at the 3 compartment sink reading 400+ ppm Quats. COS: Sanitizer sink was remade to read 200ppm Quats. Advised to use test strips while preparing solutions. CA:511-6-1.07(6)(g) - Chemical Sanitizers, Criteria (P) (g) Chemical Sanitizers, Criteria. Chemical sanitizers, including chemical sanitizing solutions generated on-site, and other chemical antimicrobials applied to food-contact surfaces shall:

1. Meet requirements specified in 40 CFR 180.940 Tolerance exemptions for active and inert ingredients for use in antimicrobial formulations (Food-contact surface sanitizing solutions) P, or

2. Meet the requirements as specified in 40 CFR 180.2020 Pesticide Chemicals Not Requiring a Tolerance or Exemption from Tolerance-Non-food determinations. P

Observed raw cut chicken breast cooling in walk in cooler with lids on tight and stacked. COS: lids were removed and pans where unstacked to allow proper cooling. CA:511-6-1.04(6)(e) - Cooling Methods (Pf, C) (e) Cooling Methods. 2. When placed in cooling or cold holding equipment, food containers in which food is being cooled shall be:

(ii) Loosely covered, or uncovered if protected from overhead contamination during the cooling period to facilitate heat transfer from the surface of the food.

Observed gnats behind ice machine and dead roach in main kitchen. Advised to properly place ice machine so water from drain pipe is not dripping directly on to floor causing standing water. CA: 511-6-1.07(5)(k) - Controlling Pests (Pf, C) (k) Controlling Pests. The presence of insects, rodents, and other pests shall be controlled to minimize their presence on the premises by: 2. Routinely inspecting the premises for evidence of pests; 4. Eliminating harborage conditions.

Current inspection report not posted at time of the inspection. C/A:511-6-1.02(1)(d) - Displaying of the Inspection Report (C)

1. The most current inspection report shall be prominently displayed in public view at all times, within fifteen feet of the front or primary public door and between five feet and seven feet from the floor and in an area where it can be read at a distance of one foot away. Advised to have posted on the wall in clear view for costumers to see.

Observed air vents and ceiling tiles unclean with dust debris build up above the single use storage. Observed floors near dry storage unclean to sight. CA: 511-6-1.07(5)(a),(b) - Good Repair, physical facilities maintained; Cleaning, Frequency & Restrictions, cleaned often enough to keep them clean (C) (5) Maintenance and Operation.

(a) Good Repair. All physical facilities shall be maintained in good repair.

(b) Cleaning, Frequency and Restrictions.

1. The physical facilities shall be cleaned as often as necessary to keep them clean and by methods that prevent contamination of food products.

2. Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of food is exposed, such as after closing. Advised to have deep cleaned and increase cleaning frequency.

Observed Servsafe certificate not post at time of inspection. C/A:511-6-1.03(3)(c) - Certification Documentation (Pf)

1. The original CFSM certificate shall be posted in public view in each food service establishment. An additional copy shall be retained on file at the food service establishment at all times, and shall be made available for inspection by the Health Authority. COS: Certificate was posted while inspector was onsite.

Observed 2 hand sink in main kitchen without soap. C/A: 511-6-1.07(3)(a) - Handwashing Cleanser, Availability (Pf) (3) Numbers and Capacities.

(a) Handwashing Cleanser, Availability. Each handwashing sink or group of two adjacent handwashing sinks shall be provided with a supply of hand cleaning liquid, powder, or bar soap. Pf COS: soap was restocked

Observed wet wiping cloth stored in hand sink basin near entry of main kitchen. C/A: 511-6-1.06(2)(o) - Using a Handwashing Sink- Operation & maintenance (Pf) (o) Using a Handwashing Sink.

1. A handwashing sink shall be maintained so that it is accessible at all times for employee use. Pf
2. A handwashing facility may not be used for purposes other than handwashing. Pf COS: Wet wiping cloth was moved to sanitizer bucket.

Observed the inside of the main ice machine and ice bin at drive thru unclean with black debris build up in direct contact with ice. Observed the soda machine at drive thru unclean with heavy black build up indirect contact with soda. Observed ice scoop holder unclean with brown substance in direct contact with ice scoop. Observed milkshake machine unclean with crusted brownish white substance build up in direct contact with milkshake mix. 511-6-1.05(7)(b) - Food Contact Surfaces and Utensils - Cleaning Frequency (P, C) (b) Equipment Food-Contact Surfaces and Utensils. 5. Except when dry cleaning methods are used as specified under subsection (7)(e) of this Rule, surfaces of utensils and equipment contacting food that is not time/temperature control for safety food shall be cleaned: (i) At any time when contamination may have occurred (ii) At least every 24 hours for iced tea dispensers including nozzles and consumer self-service utensils such as tongs, scoops, or ladles; (iii) Before restocking consumer self-service equipment and utensils such as condiment dispensers and display containers; and (iv) In equipment such as ice bins and beverage dispensing nozzles and enclosed components of equipment such as ice makers, cooking oil storage tanks and distribution lines, beverage and syrup dispensing lines or tubes, coffee bean grinders, and water vending equipment: COS: Ice was burned and all equipment was cleaned, washed and sanitized while inspector was onsite. Advised to increase cleaning frequency.

Observed the drain coming from the ice machine broken and not draining properly. Water is draining onto the floor. C/A: 511-6-1.06(2)(r) - System Maintained in Good Repair (P, C) (r) System Maintained in Good Repair. A plumbing system shall be repaired according to law; P and maintained in good repair. Advised ice machine drain shall be repaired.

Observed current inspection report posted behind promo sign out of view for customers to view. C/A:511-6-1.02(1)(d) - Displaying of the Inspection Report (C)

1. The most current inspection report shall be prominently displayed in public view at all times, within fifteen feet of the front or primary public door and between five feet and seven feet from the floor and in an area where it can be read at a distance of one foot away.

2. Food service establishments with drive-thru windows will post the current inspection report, and also have the inspection report posted so that a minimum of the top one-third of a copy of the current inspection report is visible through each window allowing customers to easily read the score, date of inspection and establishment information. Advised to have posted on the wall in clear view for costumers to see.

Observed gaskets on the cooler drawers unclean with debris build up. C/A: 511-6-1.05(7)(d) - Nonfood-Contact Surfaces (C) (d) Nonfood-Contact Surfaces. Nonfood-contact surfaces of equipment shall be cleaned at a frequency necessary to preclude accumulation of soil residues. Advised to have deep cleaned and increase cleaning frequency.

Observed floors under equipment unclean to sight with grease debris build up. C/A: 511-6-1.07(5)(a),(b) - Good Repair, physical facilities maintained; Cleaning, Frequency & Restrictions, cleaned often enough to keep them clean (C) (5) Maintenance and Operation. (a) Good Repair. All physical facilities shall be maintained in good repair. (b) Cleaning, Frequency and Restrictions.

1. The physical facilities shall be cleaned as often as necessary to keep them clean and by methods that prevent contamination of food products.
2. Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of food is exposed, such as after closing. Advised to have deep cleaned and increase cleaning frequency.

Observed cook with gloved hands preparing ready to eat food drop the to go tray on the floor and pick it then return to preparing food. Corrective Action: 511-6-1.03(5)(c) - When to Wash (P) (c) When to Wash.

1. Food employees shall clean their hands and exposed portions of their arms immediately before engaging in food preparation including working with exposed food, clean equipment and utensils, and unwrapped single-service and single-use articles P and (iv) After coughing, sneezing, using a handkerchief or disposable tissue, using tobacco, eating, or drinking, except for drinking from a closed beverage container and the container is handled to prevent contamination of the hands; P (v) After handling soiled equipment or utensils; P (vi) During food preparation, as often as necessary to remove soil and contamination and to prevent cross contamination when changing tasks; P (vii) When switching between working with raw food and working with ready-to-eat food; P (viii) Before donning gloves to initiate a task that involves working with food; P and (ix) After engaging in other activities that contaminate the hands. P CORRECTED ONSITE: READY TO EAT FOODS WERE DISCARDED, GLOVES WERE REMOVED AND HANDS WERE WASHED PROPERLY BEFORE RETURNING TO WORK.
2. All employees shall wash hands before leaving the restroom. All food employees leaving the restroom shall wash their hands again upon re-entering the food preparation area. P

Hot water not working at employee hand wash sink near front service area. Corrective action: 511-6-1.06(1)(g),(h) - Water Supply, Capacity; Pressure (Pf) (g) Capacity.

1. The water source and system shall be of sufficient capacity to meet the peak water demands of the food service establishment. Pf

2. Hot water generation and distribution systems shall be sufficient to meet the peak hot water demands throughout the food service establishment. Pf (h) Pressure. Water under pressure shall be provided to all fixtures, equipment, and nonfood equipment that are required to use water except that water supplied as specified under subsection (1)(k)1 and 2 to a temporary food service operation or in response to a temporary interruption of a water supply need not be under pressure. Pf ADVISED TO HAVE REPAIRED.

Current permit inspection not post. Corrective Action: 511-6-1.02(1)(f)(1) - Permit, Displayed (C)

1. Post the permit in a location in the food service establishment that is conspicuous to consumers

Observed salad mix(46F), sliced tomato (46F), shredded cheese (44F), and 6 premade salads(54F) stored on cold table line not holding a TCS temp of 41F or below. Corrective Action: 511-6-1.04(6)(f) - Time/Temperature Control for Safety; Cold Holding (P) (f) Time/Temperature Control for Safety Food, Hot and Cold Holding. Except during preparation, cooking, or cooling, or when time is used as the public health control, time/temperature control for safety food shall be maintained at 41°F (5°C) or below or 135°F (57°C) or above, except that roasts cooked to a temperature and for a time specified in subsection (5)(a)2 of this Rule and reheated using the same temperature and time conditions as cooking may be held at a temperature of 130°F (54°C) or above. Corrected onsite: Items were moved to walk in freezer to chill to: premade salad(41F), sliced tomato(40F), shredded cheese (40F), salad mix was discarded.

Upon entering restroom paper towels were not available. Corrective Action:511-6-1.07(3)(b) - Hand Drying Provision (Pf) (b) Hand Drying Provision. Each handwashing sink or group of adjacent handwashing sinks shall be provided with:

1. Individual, disposable towels; Pf

2. A continuous towel system that supplies the user with a clean towel; Pf

3. A heated-air hand drying device; Pf or

4. A hand drying device that employs an air-knife system that delivers high velocity, pressurized air at ambient temperatures.

Corrected onsite: Batteries were added to both machines. Advised paper towels shall be available at all times.

Observed 2 employees wearing rings with stones. Corrective Action: 511-6-1.03(5)(g) - Jewelry (C) (g) Jewelry. Except for a plain ring such as a wedding band food employees may not wear jewelry including medical information jewelry on their arms and hands while preparing food. Corrected onsite: rings were removed and employees washed hands before returning to work.