Bojangles #1297

Observed door at the back of the facility with gaps at the bottom. Manager was advised to replace door sweep. 511-6-1.07(2)(m) - Outer Openings Protected (C) (m) Outer Openings, Protected.

1. Except as specified in paragraphs 2 through 5 of this subsection, outer openings of a food service establishment shall be protected against the entry of insects and rodents by:

(i) Filling or closing holes and other gaps along floors, walls, and ceilings;

(ii) Closed, tight-fitting windows; and

(iii) Solid, self-closing, tight-fitting doors.

2. The requirements in paragraph 1 of this subsection does not apply if a food service establishment opens into a larger structure, such as a mall, airport, or office building, or into an attached structure, such as a porch, and the outer openings from the larger or attached structure are protected against the entry of insects and rodents.

3. Exterior doors used as exits need not be self-closing if they are:

(i) Solid and tight-fitting;

(ii) Designated for use only when an emergency exists, by the fire protection authority that has jurisdiction over the food establishment; and

(iii) Limited-use so they are not used for entrance or exit from the building for purposes other than the designated emergency exit use.

4. Except as specified in paragraphs 2 and 5 of this subsection, if the windows or doors of a food service establishment, or of a larger structure within which a food service establishment is located, are kept open for ventilation or other purposes or a temporary food service establishment is not provided with windows and doors as specified under paragraph 1 of this subsection, the openings shall be protected against the entry of insects and rodents by:

(i) 16 mesh to 1 inch (16 mesh to 25.4 mm) screens;

(ii) Properly designed and installed air curtains to control flying insects; or

(iii) Other effective means.

5. The requirement in paragraph 4 of this subsection does not apply if flying insects and other pests are absent due to the location of the establishment, the weather, or other limiting condition.

Observed handwashing sink leaking around faucet. 511-6-1.06(2)(r) - System Maintained in Good Repair (P, C) (r) System Maintained in Good Repair. A plumbing system shall be repaired according to law; P and maintained in good repair.

Observed excessive black accumulation in wells of steam table and grease accumulation on surface underneath grill. Also observed food accumulation at the bottom of the reach-in cooler in biscuit making station and in reach-in freezer.511-6-1.05(7)(a)2,3 - Equipment, Food/Nonfood-Contact Surfaces, and Utensils, food-contact surfaces of cooking equipment & nonfood-contact surfaces free of accumulations (C) 2. The food-contact surfaces of cooking equipment and pans shall be kept free of encrusted grease deposits and other soil accumulations.

3. Nonfood-contact surfaces of equipment shall be kept free of an accumulation of dust, dirt, food residue, and other debris.

Observed employees prepping food items wearing jewelry around the wrist. Manager began the process of informing employees to remove jewelry from the wrists. 511-6-1.03(5)(g) - Jewelry (C) (g) Jewelry. Except for a plain ring such as a wedding band food employees may not wear jewelry including medical information jewelry on their arms and hands while preparing food.

Observed coffee filters uncovered and not inverted. Manager inverted item. 511-6-1.05(10)(e)1&3 - Single-Service/Single-Use items stored 6" off floor in clean, dry location (C) (e) Equipment, Utensils, Linens, and Single-Service and Single-Use Articles.

1. Except as specified in paragraph 4 of this subsection, cleaned equipment and utensils, laundered linens, and single-service and single-use articles shall be stored:

(i) In a clean, dry location;

(ii) Where they are not exposed to splash, dust, or other contamination; and

(iii) At least 6 inches (15 centimeters) above the floor. 3. Single-service and single-use articles shall be stored as specified under paragraph 1 of this subsection and shall be kept in the original protective package or stored by using other means that afford protection from contamination until used

Observed missing drain plug. 511-6-1.06(5)(o),(p) - Using Drain Plugs; Maintaining Refuse Areas (C) (o) Using Drain Plugs. Drains in receptacles and waste handling units for refuse, recyclables, and returnables shall have drain plugs in place.

(p) Maintaining Refuse Areas and Enclosures. A storage area and enclosure for refuse, recyclables, or returnables shall be maintained free of unnecessary items and clean.

Observed vents containing and dripping condensation in main kitchen area. 511-6-1.05(2)(n) - Exhaust Ventilation Hood Systems, designed to prevent grease or condensation from dripping on food/equipment (C) (n) Exhaust Ventilation Hood Systems. Exhaust ventilation hood systems in food preparation and warewashing areas, including components such as hoods, fans, guards, and ducting shall be designed to prevent grease or condensation from draining or dripping onto food, equipment, utensils, linens, and single-service and single-use articles.

Observed drunken out of plastic bottles of water on prep areas throughout the kitchen area. 511-6-1.03(5)(j)1&2 - Eating, Drinking, or Using Tobacco (C) (j) Hygienic Practices.

1. Employees shall not use tobacco in any form, or electronic devices that simulate tobacco smoking, while engaged in food preparation or service, nor while in areas used for equipment or utensil washing and storage, food preparation or food storage. Employees shall only use tobacco products or electronic devices that simulate tobacco smoking in approved designated areas.

2. Employees shall consume food only in approved designated areas separate from food preparation and serving areas, equipment or utensil areas and food storage areas. However, drinking from a single service beverage cup with a secure lid and straw that is handled to prevent contamination of the employee’s hands, the container, exposed food, clean equipment, utensils and linens, unwrapped single-service and single-use articles will be allowed.

Observed handwashing sinks in women's restroom below 100F. The highest temperature reached was 84F before it fell.

Observed pink and black accumulation on interior ceiling of ice machine.

Observed quaternary ammonium sanitizer in 3-compartment sink with concentration at 0 ppm. Sanitizer was low. Manager placed new bag of sanitizer into compartment.

Observed wiping cloths stored in quaternary ammonium sanitizer solution below 200 ppm. Manager changed out solution.

Observed current inspection report not posted in drive-thru and old inspection report posted within the facility.

Observed loose faucet in men's restroom.

Observed white substance and debris accumulation on interior of ice machine door.

Observed no thermometer in the warmest area of the walk-in cooler and the reach-in cooler located at the at the drive-thru.

Observed wiping clothes stored in a Quat sanitizing solution below 200 PPM. Manger changed sanitizer solution out of bucket.

Observed water for handwashing sinks reach 84F in the men's restroom, 90F in the women's restroom, and 82F at the front for the kitchen. Hot water must be at least 100F.

Observed no hand drying provisions at front hand sink. PIC restocked paper towels (COS).

Raw chicken stored in walk in cooler uncovered.

Burnt food debris under foo containers in steam able by drive-thru.

TCS food items stored in the reach in cooler under grill found out of temperature (greater than 41F). COS: PIC removed items.